Amid California Drought, Oil Industry Wastewater Attracts New Scrutiny

June 1, 2015 IAQLiveWire
Thursday, 28 May 2015 13:34

State and federal authorities move to tame use of aquifers as oil field dumps.


Photo © J. Carl Ganter / Circle of Blue
Kern County is the center of California’s oil industry. The industry’s wastewater disposal practices have come under greater scrutiny in the fourth year of California’s drought emergency. Click image to enlarge.

By Brett Walton
Circle of Blue

In the fourth year of an unrelenting drought emergency, every use of water in California is being put under the microscope. Watering a lawn, filling a pool, washing a car, growing food — all are familiar practices now viewed with a more critical eye.

The same is true of California’s oil industry, the nation’s third largest. Centered in Kern County, at the southern end of the Central Valley, the industry’s relationship to water is bound by a surprising ratio. The main product, by volume, from California’s oil fields is not oil. It’s water. For every barrel of oil pumped from the ground, fifteen barrels of water, on average, come to the surface.

Another surprise, perhaps, for most observers is that hydraulic fracturing is not responsible for all that water. Fracking often stirs deep passions, but the drilling technique uses very little water in California, only 1.7 million barrels (70 million gallons) in 2014.

The more significant challenge is getting rid of what’s known in the oil industry as “produced water,” the chemical- and salt-laced liquid byproduct found in the same deep geologic zones that contain oil and natural gas. When wells are drilled to the depth of the hydrocarbon reserves, a torrent of produced water, typically millions of gallons, rushes up the borehole to the surface.

Disposing of so much produced water, which generally is saturated with toxic compounds and salt, has proved problematic. In the last year, federal and state audits in California found a number of injection wells and evaporation ponds — two primary methods of wastewater disposal — that were dumping water into protected groundwater sources or operating without permits. Though state officials say there are no documented cases of current drinking water sources being polluted by oil industry waste, the violations take on greater urgency during a historic drought in which even marginal waters are increasing in value. State regulators now face pressure from the U.S. Environmental Protection Agency and environmental groups to exercise tighter control over the oil industry’s wastewater.

Which Method of Disposal Makes Sense?

State authorities are dealing with two questions about the disposal of produced water. Should the tide of waste be dumped into aquifers or reused? And what sorts of monitoring and oversight are necessary to protect drinking water sources from contamination?

California Kern County oil industry pump jacks energy
Photo © J. Carl Ganter / Circle of Blue
Tank farms in Kern County hold thousands of barrels of process water for use in oil production. Click image to enlarge.

The goal of the increased scrutiny is to keep injected water in place. Steve Bohlen, the Department of Conservation’s oil and gas supervisor, said that the department is reviewing each of the questionable wells and requiring operators to submit data on the chemical composition of injected fluids, water quality in the aquifer, and the location of any nearby drinking water wells.

“Water injected into a disposal well, properly permitted, should have geologic confinement so the wastewater is not traveling long distances and is not mixing with water of higher quality,” Bohlen told Circle of Blue.

Though state officials are acting with renewed vigilance, critics say that their remedies are too slow or too timid.

“The state is starting to deal with these issues whereas in the past they were ignored,” Andrew Grinberg, an analyst at Clean Water Action, told Circle of Blue. Clean Water Action published a report in November 2014 on the pollution threats that unlined disposal ponds pose to air quality and groundwater.

But Grinberg said that the drought, which is forcing the state to justify the use of every drop of water, requires authorities to take stronger action, such as immediately halting injection in illegal wells or banning the use of unlined ponds.

“The magnitude of these issues in a drought makes oil waste disposal a higher priority than the state is acknowledging,” Grinberg asserted. “While they are conducting an investigation, they are allowing discharge to continue. That response is lacking and inadequate.”

The Response

California’s oil industry produced 3.3 billion barrels (140 billion gallons) of wastewater in 2014, according to the state Department of Conservation. That’s more than 16 times the 204 million barrels of oil produced last year in California, according to the federal Energy Information Administration. Nearly two-thirds of the produced water is pumped back into the oil fields as steam or water, to maintain pressure in the wells and keep the heavy hydrocarbons flowing.

California oil industry wastewater produced water infographic Kaye LaFond
Graphic © Kaye LaFond / Circle of Blue
For every barrel of oil pumped in California, roughly 15 barrels of water flow out of the well. Click image to enlarge.

The remainder of the produced water — more than 1 billion barrels — goes in several directions. Nearly 30 percent is injected into the state’s roughly 1,750 underground disposal wells, the equivalent of throwing away the water because it is removed from the hydrologic cycle. Approximately 5 percent of the wastewater is dumped into evaporation ponds that speckle the desert flatlands of Kern County.

A small portion, less than 5 percent, is treated and sent to irrigation districts, to be blended with cleaner sources and used for irrigation. This practice — and the residual contaminants in the irrigation water — has invited greater scrutiny as well.

State assessments center on injection wells and evaporation ponds because they pose the biggest risk to groundwater.

Oil field wastewater is regulated as a Class II fluid under the U.S. Environmental Protection Agency’s underground injection control program, which is part of the Safe Drinking Water Act and is designed to protect drinking water sources from contamination. The EPA has granted 40 states the authority to oversee the permitting and enforcement of Class II wells under the underground injection control program. California earned this power, called primacy, in 1983.

Federal Intervention

Deficiencies in California’s injection well program, which is run by the Department of Conservation’s Division of Oil, Gas, and Geothermal Resources (DOGGR), came to light last summer. EPA audits of the program in 2011 and 2012 found an unspecified number of wells that were injecting wastewater into protected aquifers. Those results were shared with DOGGR, which followed with its own analysis. In a letter dated July 17, 2014, and sent to the leaders of the California Natural Resources Agency and the California Environmental Protection Agency, officials in the U.S. EPA’s Region 9 office asked for a comprehensive review of the state’s injection well program.

California Kern County oil industry pump jacks energy
Photo © J. Carl Ganter / Circle of Blue
A pump jack pulls oil from beneath the Kern County soil. For every barrel of oil, roughly 15 barrels of water come out of the ground in California. Click image to enlarge.

One of the key tests for protection is water quality in the receiving aquifer, as measured in total dissolved solids (TDS). Federal regulations protect aquifers with less than 10,000 parts per million TDS. Drinking water, by comparison, is typically less than 300 parts per million, so the standard is designed to guard a range of waters that might be too salty to use today but, with adequate treatment, could be future water sources.

DOGGR officials are now reviewing the failed permitting system. Analysis completed since receiving the EPA letter in July determined that 452 wells — roughly a quarter of the wells operating in the state — injected wastewater into aquifers that should not have been used as an underground garbage can.

One hundred fifty-five wells were injecting into aquifers with less than 3,000 TDS. Regulators have closed 23 of these wells. The remainder must close by October 15 or ask the state for an exemption. Bohlen said that the state is unlikely to grant any exemptions, though a few are possible. An aquifer can be exempt if well operators prove that the water is saturated with hydrocarbons, if it is too deep for economic use of the water, or if there is no reasonable expectation that it could serve as a public water supply.

The 297 wells that are injecting into aquifers with TDS between 3,000 and 10,000 parts per million must close by February 15, 2017. Regulators are conducting more thorough assessments on 207 of these wells because they are injecting water relatively close to the surface – at depths of less than 457 meters (1,500 feet). As groundwater tables have declined during the drought, these formerly marginal sources of water are now becoming more valuable and may need additional protection.

The reassessment is a difficult task, the EPA noted. “Our frequent dialogue and your efforts in the last six months have illuminated the breadth and complexity of the challenges and the substantial workload faced by the State Agencies in overcoming the program’s deficiencies,” wrote Jane Diamond, director of the EPA Region 9 water division, in a December 22, 2014 letter.

Still, the timetable for action is too slow for a host of environmental groups. Earlier this month, the Center for Biological Diversity, Earthjustice and the Sierra Club filed suit against DOGGR, seeking to shut down the 452 injection wells.

State Reforms Proposed

Lawmakers are pushing reforms as well. This week, the California Assembly Appropriations Committee will debate AB 356, a bill that adds new groundwater monitoring requirements for disposal wells. It was approved by the Natural Resources Committee by a vote of 6 to 2. The groundwater monitoring bill follows SB 1281, a law passed last September that strengthened reporting standards for the oil industry’s wastewater practices. The first deadline to report water volumes, chemical compositions, and use of recycled water under SB 1281 comes in June.

Lawmakers have other options for action. Asked if the Department of Conservation would write regulations that would force the oil industry to clean up and recycle more of its wastewater rather than inject it, Bohlen, the oil and gas supervisor, said that such an action would be beyond the department’s authority.

No disposal wells at all is not something that you can have if you want to have oil production in the state. These two go together.”

–Steve Bohlen, oil and gas supervisor
California Department of Conservation

“Creating financial incentives through regulations is a policy call,” Bohlen said. “That’s for the administration or the Legislature and would not be in our bailiwick.”

Bohlen expects that injection wells will be part of the industrial cycle in California for the foreseeable future. Though companies are developing recycling technologies that eliminate discharge, there are no commercial operations yet in California. The most common technology today, called reverse osmosis, produces one gallon of concentrated brine for every gallon of pure water. Even if recycling increases, the brine remains a problem.

“No disposal wells at all is not something that you can have if you want to have oil production in the state,” Bohlen said. “These two go together.”

Waste Ponds Also Assessed

Evaporation ponds, the second disposal method, are also receiving a closer look. The Central Valley Regional Water Quality Control Board’s Fresno office, which has jurisdiction over the state’s prime oil-producing territory, is requiring evaporation pond operators to submit water quality tests by June 15 for the 619 active ponds, meaning those with fluid in them. All active ponds are being reviewed and must be properly permitted by December 2016 or face closure, according to Clay Rodgers, the Central Valley regional official in charge of oil wastewater.

Last spring during a field inspection, officials at the Central Valley Regional Water Quality Control Board found disposal ponds that they were not aware of. Disposal ponds range in size from a corner office to a football field. Some are lined to prevent waste from seeping into the ground; others are not.

“We said to ourselves that we need to look more closely at this,” Rodgers told Circle of Blue.

Rodgers and other officials looked at aerial photographs, conducted more field inspections, drew more information from the DOGGR database, and called oil companies. They concluded that the waste ponds needed a comprehensive review.

The office has filed 95 enforcement orders against unpermitted ponds. These orders will all be heard by the end of the year, and the pond operators will have until December 2016 to comply with permit requirements such as water quality standards, sampling and reporting schedules, and prohibitions on storing hazardous waste.

The office did not have enough money to handle the assessment on its own, Rodgers said. It had to pull in people from other programs to work on the inspections and enforcement. The governor’s next budget offers some assistance – funding for six new staff positions to address the ponds, Rodgers said.

The highest priority ponds are on the east side of the San Joaquin Valley where groundwater has a greater chance of contaminating farm fields or drinking water wells. As with injection wells, Rodgers said he does not know of any drinking water wells contaminated by seepage from waste ponds. At least one farm in Kern County, however, has suffered polluted groundwater. In 2009, a jury ordered Aera Energy, a Bakersfield company, to pay Fred Starrh, an almond grower, $US 9 million in damages resulting from oil wastewater that was dumped in unlined ponds and spoiled his orchards.

For Grinberg and his Clean Water Action colleagues, the waste ponds are an example of an outdated practice that should be banned. But state officials are not willing to take that step. For Rodgers, the goal is simple: to keep the waste in the ponds.

Author: Brett Walton  is a Seattle-based reporter for Circle of Blue. He writes our Federal Water Tap, a weekly breakdown of U.S. policy. Interests: Southwest, Pacific Northwest, Pricing, Infrastructure.

Email: Brett Walton  :: Follow on Twitter :: More Articles

The post Amid California Drought, Oil Industry Wastewater Attracts New Scrutiny appeared first on IAQnet Live Wire.

Previous Post
American Petroleum Institute Ads Target Smog Rules
American Petroleum Institute Ads Target Smog Rules

BY Marcia G. Yerman on June 8, 2015 In a move that seems ripe for a John...

Next Post
Troubling Interdependency of Water and Power